ICS13.030.10

CCSZ05

團體標準

T/CACE0117—2024

改性磷石膏混合料

Modifiedphosphogypsummixture

2024?01?24發布2024?01?24實施

中國循環經濟協會發布

中國標準出版社出版

T/CACE0117—2024

目次

前言··························································································································Ⅲ

1范圍·······················································································································1

2規范性引用文件········································································································1

3術語和定義··············································································································1

4技術要求·················································································································2

5試驗方法·················································································································5

6檢驗規則·················································································································6

7包裝、標志、運輸和貯存·······························································································6

附錄A（規范性）干濕循環強度試驗方法··········································································8

附錄B（規范性）水穩定性試驗方法···············································································10

附錄C（規范性）凍融試驗方法·····················································································11

附錄D（規范性）含水率試驗方法··················································································13

附錄E（規范性）完整試件浸出試驗方法·········································································15

附錄F（規范性）破碎試件浸出試驗方法·········································································16

參考文獻····················································································································18

Ⅰ

T/CACE0117—2024

前言

本文件按照GB/T1.1—2020《標準化工作導則第1部分：標準化文件的結構和起草規則》的規

定起草。

請注意本文件的某些內容可能涉及專利。本文件的發布機構不承擔識別專利的責任。

本文件由中國循環經濟協會提出并歸口。

本文件起草單位：湖北九廈環?？萍加邢薰?、湖北九廈低碳產業發展研究院有限公司、九廈新材

料湖北荊門有限公司、九廈新型建材科技（枝江）有限公司、宜昌市建筑節能推廣中心、宜昌市信息與標

準化所、荊門市建筑節能管理辦公室、安寧磷石膏應用技術中心、中國地質大學（武漢）、武漢工程大學、

云南大學、安徽建筑大學、上海理工大學、貴州大學、當陽市風景園藝工程有限責任公司、宜昌市虹源檢

測有限公司、武漢市政工程設計研究院有限責任公司、中南冶金地質研究所、葛洲壩集團試驗檢測有限

公司、湖北千里目檢測技術有限公司、湖北源晨環境工程有限公司、廣西川金諾化工有限公司、三一汽

車制造有限公司、湖北六國化工股份有限公司、湖北徽陽新材料有限公司、湖北新洋豐新型建材科技有

限公司、貴州安捷豐茂商貿物流股份有限公司、青島科尼樂機械設備有限公司、四川綠居天海新型建材

有限公司、湖北九廈新材料科技有限公司。

本文件主要起草人：徐志、李作斌、章鴻、張文勝、程林、汪青山、段平、林俊濤、楊華金、張華麗、

任駿、王愛國、闞黎黎、楊睿、王稚陽、許銀行、周楚堯、楊民、陳衛烈、王峰、王武科、周安琪、秦建平、

廖波、顏艷冰、吳波、蘇浩、施如意、于周帥、張勇、阮懷貴、韓帆、許進沖、林浩、李維峰、汪少華、高樹風、

徐立靖、任滿春、陳誠、翟申平、楊翔、陳孝剛、姜學軍、吳鏑、胡萌。

Ⅲ

T/CACE0117—2024

改性磷石膏混合料

1范圍

本文件規定了改性磷石膏混合料的技術要求、試驗方法、檢驗規則和包裝、標志、運輸及貯存等。

本文件適用于改性磷石膏混合料的制備。

2規范性引用文件

下列文件中的內容通過文中的規范性引用而構成本文件必不可少的條款。其中，注日期的引用文

件，僅該日期對應的版本適用于本文件；不注日期的引用文件，其最新版本（包括所有的修改單）適用于

本文件。

GB175通用硅酸鹽水泥

GB/T5484石膏化學分析方法

GB8978污水綜合排放標準

GB/T23349肥料中砷、鎘、鉻、鉛、汞含量的測定

GB/T23456磷石膏

GB/T25499城市污水再生利用綠地灌溉水質

CJ/T486土壤固化外加劑

HJ557固體廢物浸出毒性浸出方法水平振蕩法

JTG3430公路土工試驗規程

JTG3441公路工程無機結合料穩定材料試驗規程

JTG/TF20公路路面基層施工技術細則

3術語和定義

下列術語和定義適用于本文件。

3.1

磷石膏phosphogypsum

CaSO2HO

以磷礦石為原料通過濕法制取磷酸時得到的主要成分為二水硫酸鈣（4·2）的副產物。

3.2

凈化磷石膏purifiedphosphogypsum

經過水洗、中和、浮選、焙燒等工藝處理后，能滿足綜合利用相關指標要求的磷石膏。

3.3

磷石膏混合料改性劑phosphogypsummixturemodifier

以乙烯基聚合物、硅酸鹽、聚丙烯酰胺、表